Complete structural refit (interior and exterior), including a 4m hull extension in 2002 (naval architecture by the very well respected Richard Le Sarre.
Complete redesign of the sundeck by the world famous Ed Dubois of Dubois Yachts. This included the removal of the aft radar arch and the integration of this into the main arch, and the creation of a tanning area aft. Other works undertaken at the same included a full repaint, new capping rails, new teak decking on the boat deck, larger stabilisers fitted, and new galley equipment (hobs, ovens, fridges).
5yr Lloyds hull and machinery survey, bridge and radio room refurbished, new exterior cushion covers, Fleet 55 satellite communication system fitted.
Running gear - removed and realigned shafts and props, also realigned gearboxes.
Main engines overhauled.
Hamman system installed.
Installed touch screen control system for operating hamman, a/c system, water tanks, fuel tanks, security system, generators and main engine exhaust valves.
New HEM watermakers installed.
Overhaul of both windlasses and aft capstans.
Replaced A/C compressor.
Galley completely refitted winter 2006.
Paint job by Pinmar. 90% of the yacht repainted.
Main exhaust systems refurbished - all main engine exhaust system removed and replaced with new stainless steel system.
Generators removed and replaced with 2 Kilopac 100kw models.
Generator controls - installed gensys electronic control system for switching between shore power and gens, system also controls load sharing.
Throttle controls replaced with ZF electronic throttles.
Service tanks cleaned and repainted including fresh water, grey water, black water and white water.
Sundeck awning replaced.
2010 - 2011
Prepared and applied prop speed on shafts, propellors and bow thruster.
New bilge pump fitted on the port side.
Fresh water tanks non return Valve (hammering).
Both AC raw water pump elect motors serviced.
Oil-Water Separator Motor/Pump serviced.
Steering gear cooling fan serviced.
All six air filters for Main Engine cleaned.
Inspection of hull and underwater fittings (rudder, propeller, etc).
Modified hull for separate discharge for oil-water separator - install through hull flange to accept 1" 1/2 valve. Lloyds approved.
Props removed and balanced.
Shaft removed and replaced bearings & alignment.
Removed and replaced shaft seals.
Re-painted galley, added sight glass to the day tank, installed calibrated Lloyds approved sight glass to day tank on the port side, situated just above manhole cover.
Teak decks installed.
Cleaned and painted fresh water tank (1) and other domestic tanks (5).
Cleaned ME heat exchangers.
Modified port bilge pump piping to allow external pumping of the bilge.
Modified port forward sea suction to put oil-water separator on its own suction.
New awning on boat deck.
Oil-Water separator 2 year service.
PLC up grades - AC valve settings - Hamman modification.
Redo AC lagging.
Remedied water flow consistency problem.
Replaced corroded pipe on port Gearbox inlet to cooler.
Generators fully serviced.
Re-sprayed boat deck table.
Serviced both windlasses (Lofrans Supper Erecolle C).
Steam cleaned day tank.
Varnished dining table on Sun Deck.
Covered holes in leather in bridge.
Serviced aft domestic fresh pump.
Fore deck locker lids replaced.
Fabricated and installed trim on 3 deck refrigerators.
Removed and repaired crew sink pipe.
Gear box inlet cooling pipe removed and replaced.
Replaced port strut rope guard.
Inspected glass windows on tank tops.
Pressure tested bilge pump cross over line.
Replaced ME and emergency Batteries.
Dive equipment serviced.
Safety equipment serviced.
Life raft serviced.
Fleet 55 replaced with new dome and controls.
Main engine raw water intakes, replaced corroded sections and installed isolation valve between engines, Lloyds approved.
Blisters in main deck stripped back and refinished, any areas of corrosion in vicinity also knocked back and refinished.
Lazarette and engine room floor plate and frames stripped back and refinished.
Davit - removed and replaced hoses and fittings that were leaking air into the system
Port gearbox- shafts removed, gearbox and struts had chockfast broken out and realigned by Quantum, gearbox and struts re chockfasted into place, shafts refitted.
Variable speed drives on the a/c compressors installed.
Cathelco system - new anodes installed and tested.
Gensys system software adjusted to enable the generators to load up to optimum.
Watermaker fully serviced.
Engine pre heaters replaced.
Alfa laval fully serviced.